Chartiers, PA to Bethlehem, PA is 294.7 miles and takes about 5h 57m via Pennsylvania Turnpike, William Penn Highway, and American Legion Memorial Highway, with a fuel budget near $54 and enough daylight to finish in a day. This trip stays within the Northeast region, entirely within Pennsylvania. Expect a mix of highway driving and surface roads as you make your way across the state. It's a solid option for a single-day trip if you're looking for a straightforward drive between these two points in PA.
Trip Pace
Same-day drive is realistic
A same-day return is possible, but it will make for a full day on the road.
Break Rhythm
1 planned break
Plan on a short reset every 3 to 4 hours to stay fresh behind the wheel.
Midpoint
147.4 miles from Chartiers, PA
A natural place for your longest stop of the day
, about 2h 57m into the drive
.
Main Roads
Road
Distance
Duration
Pennsylvania Turnpike
152 mi
2h 47m
William Penn Highway
42.8 mi
50m
American Legion Memorial Highway
22.5 mi
27m
Dwight D Eisenhower Highway
19.3 mi
26m
I 81
12.7 mi
15m
Lehigh Valley Thruway
10.3 mi
14m
78th Division Highway
7.6 mi
8m
Mon/Fayette Expressway
6 mi
6m
Longest stretch:
Pennsylvania Turnpike
— 152 mi, about 2h 47m
Traffic on I-81
Hour-of-day weekday pattern from 28 FHWA count stations on your route.
Peak
4 PM
~2,785 veh/hr typical
Quietest
1 AM
~380 veh/hr
Peak-to-quiet ratio
7.3×
busier at peak than in the quiet hours
12a6anoon6p11p
Averaged across 52 weeks of 2023 FHWA Travel Monitoring Analysis System data. Weekday hours only (Mon–Fri).
Turn-by-Turn Driving Directions
Step-by-step road directions between Chartiers, PA and Bethlehem, PA.
1
Start on Chartiers Road
0.4 mi·53 sec·Chartiers Road
2
Continue on Seven Creeks Road
362 ft·10 sec·Seven Creeks Road
3
Continue on Castile Run Road
0.9 mi·2 min·Castile Run Road
4
Continue on Center Street
0.3 mi·42 sec·Center Street
5
Continue on SR 2039
2.2 mi·4 min·Main Street
6
At end of road, turn left onto PA 88
1.7 mi·2 min·Front Street
7
Continue on PA 88
0.5 mi·42 sec·Water Street
8
Turn straight onto PA 88
1.2 mi·1 min·Front Street
9
Continue on PA 88
3.0 mi·4 min·Low Hill Road
10
Turn left onto PA 88
0.9 mi·1 min·PA 88
11
Merge onto PA Tpke 43; PA 88
6.0 mi·6 min·Mon/Fayette Expressway
12
Take the exit
0.6 mi·1 min
Toward I 70 East: New Stanton
13
Merge onto I 70
19 mi·26 min·Dwight D Eisenhower Highway
Use the straight / slight right lanes.
14
Take the exit onto I 70
0.5 mi·1 min·I 70
Exit 58Toward I 70 Toll East, I 76 Toll, PATP: Harrisburg, PittsburghUse the slight right lane.
15
Keep slight left at fork onto I 70
0.4 mi·1 min·I 70
Toward I 70 East, I 76 East: Harrisburg
16
Merge onto I 70; I 76; PATP
152 mi·2 hr 47 min·Pennsylvania Turnpike
17
Take the exit
0.9 mi·2 min
Toward I 81, US 11: Carlisle, HarrisburgUse the slight right lane.
18
Keep slight left at fork
0.3 mi·54 sec
Toward US 11 North: HarrisburgUse the straight / slight right lanes.
19
Continue on US 11
1.1 mi·2 min·Harrisburg Pike
Use the straight lane.
20
Take the exit
0.3 mi·34 sec
Toward I 81 North: Harrisburg
21
Merge onto I 81
13 mi·15 min·I 81
Use the straight / right lanes.
22
Take the exit
0.2 mi·14 sec
Toward US 11, US 15: Enola, Marysville
23
Keep slight left at fork
0.3 mi·28 sec
Toward US 11 North, US 15 North: Marysville
24
Keep slight left at fork
0.4 mi·32 sec
25
Merge onto I 81
0.7 mi·1 min·George N. Wade Memorial Bridge
Use the straight / slight right lanes.
26
Continue on I 81
3.4 mi·4 min·American Legion Memorial Highway
27
Keep slight left at fork onto I 81
19 mi·22 min·American Legion Memorial Highway
Use the straight / slight right lanes.
28
Take the exit
0.7 mi·45 sec
Exit 89Toward I 78 East: Allentown
29
Continue on I 78
7.6 mi·8 min·78th Division Highway
30
Continue on I 78; US 22
43 mi·50 min·William Penn Highway
Use the straight lane.
31
Keep slight right at fork onto US 22
10 mi·14 min·Lehigh Valley Thruway
Exit 51Toward US 22 East: Pennsylvania Turnpike, LVI AirportUse the slight right lane.
32
Take the exit
0.2 mi·26 sec
Toward PA 378 South: Bethlehem, Schoenersville RoadUse the slight right lane.
33
Keep slight right at fork
0.2 mi·21 sec
Toward PA 378 South: BethlehemUse the straight / slight right lanes.
34
Continue on PA 378
1.8 mi·2 min·Bethlehem Spur Route
35
Take the exit
0.2 mi·33 sec
Exit 2Toward Eighth AvenueUse the slight right lane.
36
Turn right onto 8th Avenue
0.1 mi·22 sec·8th Avenue
37
Turn left onto West Union Boulevard
1.0 mi·2 min·West Union Boulevard
38
Turn left onto Center Street
423 ft·11 sec·Center Street
39
Turn right onto East Goepp Street
0.3 mi·49 sec·East Goepp Street
40
Turn right onto Linden Street
57 ft·1 sec·Linden Street
41
Arrive at destination
Linden Street
Trip Plan
Given the 5h 57m estimated duration, leaving Chartiers, PA in the morning is your best bet to arrive in Bethlehem, PA with plenty of daylight. The longest stretch on the Pennsylvania Turnpike is 152 miles, so plan your first break after that segment. With a fuel cost estimated at $54, ensure your tank is full before you depart. Since this is a single-day trip, you have flexibility, but keeping an eye on traffic, especially as you approach the Lehigh Valley, is advisable.
Morning Departure
An early start around 7-8 AM gets you there with plenty of daylight left.
Evening Departure
A late afternoon start means arriving after dark. Morning is better.
You can normally do this drive in one day.
Plan roughly 1 meaningful break for fuel, food, and rest.
The halfway point lands around 147.4 miles from Chartiers, PA, or about 2h 57m into the drive.
The longest continuous stretch on this route runs about 152 miles.
This is a comfortable same-day trip.
Departure
Before you leave
Start with fuel, water, and navigation already sorted so the first hour feels easy.
First stop
Around 65 miles or 1h 27m in
Use this first pause for coffee, a restroom break, and a quick traffic check ahead.
Halfway reset
Around 147.4 miles or 2h 57m in
This is the best place for your longest stop, a real meal, and a full fuel check.
Final approach
Final hour starts around 4h 49m
Traffic, exits, and arrival timing usually matter more near Bethlehem, PA than in the middle of the route.
Before You Leave
+
Open the route before leaving Chartiers, PA so your first major turns are already loaded.
+
Leave with enough water and a charging cable within reach, not packed away.
+
Check your fuel range against the first long segment, especially if you are starting outside city service areas.
Day 1
Settle into the route from Chartiers, PA
This is one driving day of about 294.7 miles and 5h 57m.
Your first comfortable stop window is around 65 miles from Chartiers, PA.
This route can stay practical as a one-day drive if traffic stays reasonable.
Plan about 1 real break rather than only quick fuel stops.
The longest stretch is on Pennsylvania Turnpike for about 152 miles.
Where to Stop
Rest stops, refuel points, and overnight suggestions along this route.
Place data sourced from public business listings. Hours and availability may vary.
Heads-up: tricky spots
5 of 27
5 decision points cluster between mile 37.1 and 290.9 — GPS handles the exact turns, but know they're coming. Your lane choice matters more than the turn itself.
8
37.1 mi into trip|~54m in|I 70
Take the exit onto I 70 toward I 70 Toll East, I 76 Toll, PATP: Harrisburg, Pittsburgh
Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one
Use the slight right lane.
Exit 58
Toward I 70 Toll East, I 76 Toll, PATP: Harrisb...
7
190 mi into trip|~3h 44m in
Take the exit toward I 81, US 11: Carlisle, Harrisburg
Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one
Use the slight right lane.
Toward I 81, US 11: Carlisle, Harrisburg
7
190.9 mi into trip|~3h 46m in
Keep slight left at fork toward US 11 North: Harrisburg
Highway fork - watch signs carefully. Lane positioning matters here
Use the straight / slight right lanes.
Toward US 11 North: Harrisburg
9
280.5 mi into trip|~5h 36m in|US 22 / Lehigh Valley Thruway
Keep slight right at fork onto US 22 / Lehigh Valley Thruway toward US 22 East: Pennsylvania Turnpike, LVI Airport
Highway fork - watch signs carefully. Lane positioning matters here. Multiple destination signs - pick the right one
Use the slight right lane.
Exit 51
Toward US 22 East: Pennsylvania Turnpike, LVI A...
8
290.9 mi into trip|~5h 50m in
Keep slight right at fork toward PA 378 South: Bethlehem
Highway fork - watch signs carefully. Lane positioning matters here
Use the straight / slight right lanes.
Toward PA 378 South: Bethlehem
Fuel & Cost
Regular Gas
$46.99 one way
$93.98 round trip
$4.05/gal25.4 MPG avg103 kg CO2
Fuel Type
$/gal
One Way
Round Trip
midgrade
$4.48
$52.00
$104.00
premium
$4.81
$55.78
$111.57
diesel
$4.80
$55.64
$111.29
Estimated Tolls: $20.90
Pennsylvania Turnpike
(152 mi)$19.76
Lehigh Valley Thruway
(10.3 mi)$0.72
Mon/Fayette Expressway
(6 mi)$0.42
Toll estimates based on average 2024-2025 rates. EZ-Pass/SunPass discounts may lower the actual cost.
Estimated Trip Cost (one way, 1 person)
Fuel
$47
Tolls
$21
Meals
$25–$50
Total
$93–$118
Rough estimate based on US averages. Hotel $80–$140/night, meals $25–$50/day.
Estimated CO2 emission: 103.1 kg one way.
Prices: EIA weekly data, 2026-07-13.
Driving Electric?
About $31 in charging
· 1 stop
· 67% less CO2
Vehicle Type
kWh
Stops
DC Fast
Home Charge
Average EV
88.4
1
$30.94
$14.15
Efficient EV
73.7
0
$25.79
$11.79
EV Truck/SUV
117.9
1
$41.26
$18.86
Gas CO2
103 kg
EV CO2
34 kg (67% less)
Plan for 1 charging stop. A 30-minute DC fast charge mid-route should be enough to complete the trip comfortably.
DC fast charging avg $0.35/kWh. Home charging avg $0.16/kWh. US grid CO2: 0.39 kg/kWh.
Travel Intel
Current conditions at both ends of the drive.
Forecast as of Jul 17, 2026
Origin
Chartiers, PA
Morning
in Chartiers on Sunday
Local time
11:25 AM
EDT
Current temp
70°F
Smoke
SE 0 to 5 mph32% chanceLive forecast
Beach Hazards Statement
Beach Hazards Statement issued July 17 at 3:59PM EDT until July 18 at 8:00PM EDT by NWS Cleveland OH
Flood Watch
Flood Watch issued July 17 at 1:40PM EDT until July 19 at 2:00AM EDT by NWS Mount Holly NJ
Destination
Bethlehem, PA
Morning
in Bethlehem on Sunday
Local time
11:25 AM
EDT
Current temp
86°F
Patchy Smoke
0 mph0% chanceLive forecast
Beach Hazards Statement
Beach Hazards Statement issued July 17 at 3:59PM EDT until July 18 at 8:00PM EDT by NWS Cleveland OH
Flood Watch
Flood Watch issued July 17 at 1:40PM EDT until July 19 at 2:00AM EDT by NWS Mount Holly NJ
82°F
Martinsburg, PA
147 mi in
Seasonal Notes
Summer travel usually means heavier construction, hotter rest stops, and busier weekend traffic around major cities.
Winter travel shortens daylight, so a route that looks manageable on paper can feel much longer after dark.
Holiday weekends tend to make both departure and arrival windows slower than the raw route time suggests.
Time zone
Same local time
Origin and destination are on the same clock, so arrival timing is easier to judge at a glance.
Temperature spread
16 degrees warmer at arrival
A meaningful temperature swing is a good cue to rethink layers, water, and how soon you want to arrive.
Road read
5h 57m on the road
An early start around 7-8 AM gets you there with plenty of daylight left.
Weather data from the National Weather Service. Conditions may change; check closer to your travel date.
National Parks Near This Route
Worth a detour if your schedule allows.
Appalachian National Scenic Trail
National Scenic Trail
The Appalachian Trail is a 2,190+ mile long public footpath that traverses the scenic, wooded, pastoral, wild, and culturally resonant lands of the Appalachian Mountains. Conceived in 1921, built by p...
3 mi from route
~7 min detour
Free
near mile 233.7
Park Closure: List of trail closures post-Hurricane Helene
Caution: Black Bears Frequenting the McAfee Knob Area in Virginia
Carlisle Federal Indian Boarding School National Monument
National Monument
More than 7,800 children from 140 Tribes went to the Carlisle School from 1879 to 1918. The National Park Service will collaborate with families, affiliated Tribal Nations, the US Army, historians, an...
4 mi from route
~9 min detour
Free
near mile 193.1
On Tuesday morning, September 11, 2001, the U.S. came under attack when four commercial airliners were hijacked and used to strike targets on the ground. Nearly 3,000 people tragically lost their live...
6 mi from route
~15 min detour
Free
near mile 81.3
The battle at Fort Necessity in the summer of 1754 was the opening action of the French and Indian War. This war was a clash of British, French and American Indian cultures. It ended with the removal...
23 mi from route
~58 min detour
Free
near mile 10.2
The South Fork Dam failed on Friday, May 31, 1889, and unleashed 20,000,000 tons of water that devastated Johnstown, PA. The flood killed 2,209 people but it brought the nation and the world together...
24 mi from route
~60 min detour
Free
near mile 101.6
Park data from the National Park Service API. Alerts update every 2 hours.
More Details
What kind of drive is this?
This route features 59% highway driving, meaning you'll spend a significant portion of your time on limited-access roads. The longest continuous stretch on the Pennsylvania Turnpike is 152 miles. After this, you'll transition to surface roads like the William Penn Highway and American Legion Memorial Highway, which will likely involve more local traffic and varied speed limits. Be prepared for a shift in driving conditions as you move from high-speed cruising to more varied surface street navigation.
59% highway, the rest on surface roads — varied driving throughout.
41 navigation steps total — most of the decisions cluster near the start and finish.
Longest single stretch: 152 mi on Pennsylvania Turnpike.
How Hard Is This Drive?
10/10
This route mixes highway mileage with some local-road sections near the start or finish. This route has several spots where lane changes, forks, or exits need your full attention. The trickiest moment comes around 37.1 miles in near I 70.
Driving Effort10/10
High effort - long or complex enough to need steady focus all day
Balances navigation complexity with total wheel time.
This is a demanding drive. With 27 significant decision points across 294.7 miles, you will need to stay alert - especially through interchange areas and urban stretches. Consider splitting it into segments if you are not comfortable with fast highway navigation.
Where does it get tricky?
The main spots that need attention: at 37.1 miles (I 70): Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one; at 190 miles: Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one; at 190.9 miles: Highway fork - watch signs carefully. Lane positioning matters here.
Elevation Profile
Gently rolling terrain
2,591 ft356 ft
Total Climb
2,171 ft
Total Descent
2,820 ft
Highest Point
2,591 ft
~63.1 mi in
Elevation Range
2,235 ft
Towns Mentioned on Route Signs
Based on OSRM destination-sign hints, not a full list of every settlement the road passes.
Between Chartiers, PA and Bethlehem, PA, road signs point toward Patp: Harrisburg, Pittsburgh, Harrisburg and Marysville.
Bethlehem is one of three cities, along with Allentown and Easton, that are the urban population centers of the Lehigh Valley in eastern Pennsylvania.
In the Lehigh Valley, Bethlehem borders Nazareth to its northwest, Allentown to its west, Hellertown to its southeast, and Easton to its east. The city is about 70 miles (110 km) north of Philadelphia, the sixth-largest city in the United States, and about 80 miles (130 km) west of New York City, the nation's largest city.
Top landmarks
•Bethlehem Waterworks — pump-powered public water supply
•Historic Moravian Bethlehem Historic District — complex of the oldest surviving buildings in Bethlehem, Pennsylvania
•Cathedral Church of the Nativity — church in Pennsylvania, United States
Doable as a same-day drive at 5h 57m. Total distance: 294.7 miles.
Family Friendly
Moderate complexity with 1 natural rest stops along the way.
Solo Traveler
5h 57m drive, comfortable solo distance.
Scenic Drive
Mixed highway & surface route profile with national parks nearby.
Frequently Asked Questions
The longest stretch is about 152 miles on Pennsylvania Turnpike. The full list of main roads is in the Roads section above.
Expect about $20.90 in tolls one way, starting with Pennsylvania Turnpike. Most Northeast and Midwest toll agencies accept E-ZPass; in the West and Texas, transponders like TxTag or FasTrak apply. If you do not have a transponder, cashless tolling plates will mail a bill to the vehicle's registered address — usually with a surcharge, so a rental-car toll pass is often cheaper than paying by mail.
Yes — we found about 25 rest areas or service plazas within a short detour of the route (from OpenStreetMap). See the Rest Stops tab under Nearby Places for locations and mile markers. Plan to stretch, use the bathroom, and top off fluids every 2–3 hours on longer drives.
It helps. This route has a higher-than-average number of complex decision points, which get harder in the dark. If the last hour of the trip is on surface roads or mountain grades, aim to arrive at Bethlehem, PA before sunset when you can. Check the Trip Plan for departure windows that land you in daylight.
Only with planning. This is a long drive for kids — consider splitting it into two days rather than pushing through. Plan at least 1 meaningful breaks. There are 25 rest areas along the route for bathroom stops.
The main spots that need attention: at 37.1 miles (I 70): Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one; at 190 miles: Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one; at 190.9 miles: Highway fork - watch signs carefully. Lane positioning matters here.
Yes — Appalachian National Scenic Trail, Carlisle Federal Indian Boarding School National Monument and Flight 93 National Memorial (5 total within detour distance). See the National Parks section for detour distances and tips on detours.
Not recommended in a single day. At 6.0 hours each way, a round trip means 11.9 hours of driving — that is an unsafe level of fatigue for most drivers. Plan at least one night at Bethlehem, PA before the return drive.
