New Berlin, WI to Whitehall, WI is 219 miles and takes about 4h 5m via I 94, I 90, and East-West Freeway, with a fuel budget near $34 and enough daylight to finish in a day. This trip stays within Wisconsin, connecting two points in the Midwest. It's a straightforward, mostly highway drive with a high percentage of interstate travel. You'll likely find this route efficient for getting from point A to point B with minimal fuss. Plan for a single day of travel, as the duration is manageable.
Trip Pace
Same-day drive is realistic
A same-day return is possible, but it will make for a full day on the road.
Break Rhythm
1 planned break
Plan on a short reset every 3 to 4 hours to stay fresh behind the wheel.
Midpoint
109.5 miles from New Berlin, WI
A natural place for your longest stop of the day
, about 2h into the drive
.
Main Roads
Road
Distance
Duration
I 94
77.5 mi
1h 23m
I 90
63.5 mi
1h 8m
East-West Freeway
60.2 mi
1h 4m
Ekern Street
7.1 mi
10m
State Highway 121
5.2 mi
9m
South Moorland Road
3.3 mi
6m
WI 121
0.7 mi
1m
East Main Street
0.7 mi
1m
Longest stretch:
I 94
— 77.5 mi, about 1h 23m
Traffic on I-94
Hour-of-day weekday pattern from 54 FHWA count stations on your route.
Peak
4 PM
~2,322 veh/hr typical
· worst 2,800
Quietest
1 AM
~125 veh/hr
Peak-to-quiet ratio
18.6×
busier at peak than in the quiet hours
12a6anoon6p11p
Averaged across 52 weeks of 2023 FHWA Travel Monitoring Analysis System data. Weekday hours only (Mon–Fri).
Turn-by-Turn Driving Directions
Step-by-step road directions between New Berlin, WI and Whitehall, WI.
1
Start on West National Avenue
69 ft·1 sec·West National Avenue
2
Turn sharp right onto CTH O
3.3 mi·6 min·South Moorland Road
3
Take the ramp
0.6 mi·1 min
Use the straight / slight left lanes.
4
Merge onto I 94
6.7 mi·7 min·East-West Freeway
Use the straight / slight right lanes.
5
Keep slight left at fork onto I 94
54 mi·57 min·East-West Freeway
Use the straight / slight right lanes.
6
Keep slight right at fork onto I 94
29 mi·31 min·I 94
Exit 240Toward I 39 North, I 90 West, I 94 West: Wisconsin Dells, Eau ClaireUse the straight / slight right lanes.
7
Keep slight left at fork onto I 90; I 94
63 mi·1 hr 8 min·I 90; I 94
Use the straight lane.
8
Keep slight right at fork onto I 94
48 mi·51 min·I 94
Toward I 94 West: Eau Claire, Saint PaulUse the straight lane.
9
Take the exit
0.2 mi·23 sec
Exit 98Toward WI 121, I 94 Alternate: Alma Center, Pigeon Falls
10
Keep slight left at fork
124 ft·5 sec
11
Turn left onto WI 121; CTH FF
294 ft·5 sec·State Highway 121
12
Continue on WI 121; CTH FF
0.7 mi·1 min·WI 121; CTH FF
13
Continue on WI 121
5.1 mi·8 min·State Highway 121
14
Continue on WI 121
0.7 mi·1 min·East Main Street
15
At end of road, turn left onto US 53; WI 121
7.1 mi·10 min·Ekern Street
16
Arrive at destination
US 53; WI 121; CTH D
Trip Plan
To make the most of this 4-hour drive, consider leaving in the morning to allow for a relaxed pace and potential for an early arrival. With only one recommended stop and a manageable distance, you have flexibility. The fuel cost is estimated at $34, so ensure you have enough to cover this. Keep an eye on your fuel gauge, especially before embarking on the 77.5-mile stretch on I 94, to avoid needing to pull off unexpectedly. Since it's a single-day trip, you can easily adjust your departure time based on your schedule.
Morning Departure
An early start around 7-8 AM gets you there with plenty of daylight left.
Evening Departure
A late afternoon start means arriving after dark. Morning is better.
You can normally do this drive in one day.
Plan roughly 1 meaningful break for fuel, food, and rest.
The halfway point lands around 109.5 miles from New Berlin, WI, or about 2h into the drive.
The longest continuous stretch on this route runs about 77.5 miles.
This is a comfortable same-day trip.
Departure
Before you leave
Start with fuel, water, and navigation already sorted so the first hour feels easy.
First stop
Around 48 miles or 54m in
Use this first pause for coffee, a restroom break, and a quick traffic check ahead.
Halfway reset
Around 109.5 miles or 2h in
This is the best place for your longest stop, a real meal, and a full fuel check.
Final approach
Final hour starts around 3h 15m
Traffic, exits, and arrival timing usually matter more near Whitehall, WI than in the middle of the route.
Before You Leave
+
Open the route before leaving New Berlin, WI so your first major turns are already loaded.
+
Leave with enough water and a charging cable within reach, not packed away.
+
Check your fuel range against the first long segment, especially if you are starting outside city service areas.
Day 1
Settle into the route from New Berlin, WI
This is one driving day of about 219 miles and 4h 5m.
Your first comfortable stop window is around 48 miles from New Berlin, WI.
This route can stay practical as a one-day drive if traffic stays reasonable.
Plan about 1 real break rather than only quick fuel stops.
The longest stretch is on I 94 for about 77.5 miles.
Where to Stop
Rest stops, refuel points, and overnight suggestions along this route.
Place data sourced from public business listings. Hours and availability may vary.
Heads-up: tricky spots
5 of 11
5 decision points cluster between mile 10.6 and 205.1 — GPS handles the exact turns, but know they're coming. Your lane choice matters more than the turn itself.
6
10.6 mi into trip|~14m in|I 94 / East-West Freeway
Keep slight left at fork onto I 94 / East-West Freeway
Highway fork - watch signs carefully. Lane positioning matters here
Use the straight / slight right lanes.
9
64.1 mi into trip|~1h 12m in|I 94
Keep slight right at fork onto I 94 toward I 39 North, I 90 West, I 94 West: Wisconsin Dells, Eau Claire
Highway fork - watch signs carefully. Lane positioning matters here. Multiple destination signs - pick the right one
Use the straight / slight right lanes.
Exit 240
Toward I 39 North, I 90 West, I 94 West: Wiscon...
6
93.2 mi into trip|~1h 43m in|I 90; I 94
Keep slight left at fork onto I 90; I 94
Highway fork - watch signs carefully. Lane positioning matters here
Use the straight lane.
8
156.7 mi into trip|~2h 51m in|I 94
Keep slight right at fork onto I 94 toward I 94 West: Eau Claire, Saint Paul
Highway fork - watch signs carefully. Lane positioning matters here. Multiple destination signs - pick the right one
Use the straight lane.
Toward I 94 West: Eau Claire, Saint Paul
6
205.1 mi into trip|~3h 43m in
Take the exit toward WI 121, I 94 Alternate: Alma Center, Pigeon Falls
Exit ramp - move to the correct lane early. Multiple destination signs - pick the right one
Exit 98
Toward WI 121, I 94 Alternate: Alma Center, Pig...
Fuel & Cost
Regular Gas
$32.34 one way
$64.68 round trip
$3.75/gal25.4 MPG avg77 kg CO2
Fuel Type
$/gal
One Way
Round Trip
midgrade
$4.14
$35.70
$71.41
premium
$4.72
$40.66
$81.32
diesel
$4.80
$41.35
$82.70
No toll roads detected on this route.
Estimated Trip Cost (one way, 1 person)
Fuel
$32
Meals
$25–$50
Total
$57–$82
Rough estimate based on US averages. Hotel $80–$140/night, meals $25–$50/day.
Estimated CO2 emission: 76.6 kg one way.
Prices: EIA weekly data, 2026-07-13.
Driving Electric?
About $23 in charging
· 0 stops
· 66% less CO2
Vehicle Type
kWh
Stops
DC Fast
Home Charge
Average EV
65.7
0
$23.00
$10.51
Efficient EV
54.8
0
$19.16
$8.76
EV Truck/SUV
87.6
1
$30.66
$14.02
Gas CO2
77 kg
EV CO2
26 kg (66% less)
Plan for 0 charging stops, roughly every 270 miles. Allow 25-40 minutes per stop at a DC fast charger.
DC fast charging avg $0.35/kWh. Home charging avg $0.16/kWh. US grid CO2: 0.39 kg/kWh.
Travel Intel
Current conditions at both ends of the drive.
Forecast as of Jul 18, 2026
Origin
New Berlin, WI
Late night
in New Berlin on Sunday
Local time
4:38 AM
CDT
Current temp
88°F
Mostly Sunny
NE 5 mph0% chanceLive forecast
Beach Hazards Statement
Beach Hazards Statement issued July 18 at 12:48PM CDT until July 19 at 7:00AM CDT by NWS Milwaukee/Sullivan WI
Destination
Whitehall, WI
Late night
in Whitehall on Sunday
Local time
4:38 AM
CDT
Current temp
86°F
Sunny
N 9 mph0% chanceLive forecast
Beach Hazards Statement
Beach Hazards Statement issued July 18 at 12:48PM CDT until July 19 at 7:00AM CDT by NWS Milwaukee/Sullivan WI
85°F
Merrimac, WI
110 mi in
Seasonal Notes
Summer travel usually means heavier construction, hotter rest stops, and busier weekend traffic around major cities.
Winter travel shortens daylight, so a route that looks manageable on paper can feel much longer after dark.
Holiday weekends tend to make both departure and arrival windows slower than the raw route time suggests.
Time zone
Same local time
Origin and destination are on the same clock, so arrival timing is easier to judge at a glance.
Temperature spread
2 degrees cooler at arrival
A meaningful temperature swing is a good cue to rethink layers, water, and how soon you want to arrive.
Road read
4h 5m on the road
An early start around 7-8 AM gets you there with plenty of daylight left.
Weather data from the National Weather Service. Conditions may change; check closer to your travel date.
National Parks Near This Route
Worth a detour if your schedule allows.
Ice Age National Scenic Trail
National Scenic Trail
The Ice Age National Scenic Trail spans 1,200 miles, traverses some of Wisconsin's finest geologic and glacial features, and passes through the ancestral lands of 15 Tribes. The Trail is built, manage...
25 mi from route
~63 min detour
Free
near mile 120.8
Caution: General Advisory — Flooding Possible
Caution: Averill–Kelly Creek Wilderness Segment — Dangerous Ford at New Wood River
Park data from the National Park Service API. Alerts update every 2 hours.
More Details
What kind of drive is this?
This route is 95% highway, meaning you'll spend most of your time on interstates. The longest stretch without an exit is 77.5 miles on I 94. Expect frequent exits and interchanges for much of the drive as you navigate through the Wisconsin landscape. The transition to surface roads will be minimal, occurring only in the final few miles.
95% highway — fuel and pacing are the main things to plan.
16 navigation steps total — most of the decisions cluster near the start and finish.
Longest single stretch: 77.5 mi on I 94.
How Hard Is This Drive?
7/10
This is a straightforward highway drive that stays mostly on I 94 and I 90. This route has several spots where lane changes, forks, or exits need your full attention. The trickiest moment comes around 10.6 miles in near I 94 / East-West Freeway.
Driving Effort7/10
Demanding - plan breaks and stay ahead of the key maneuvers
Balances navigation complexity with total wheel time.
This is a demanding drive. With 11 significant decision points across 219 miles, you will need to stay alert - especially through interchange areas and urban stretches. Consider splitting it into segments if you are not comfortable with fast highway navigation.
Where does it get tricky?
The main spots that need attention: at 10.6 miles (I 94 / East-West Freeway): Highway fork - watch signs carefully. Lane positioning matters here; at 64.1 miles (I 94): Highway fork - watch signs carefully. Lane positioning matters here. Multiple destination signs - pick the right one; at 93.2 miles (I 90; I 94): Highway fork - watch signs carefully. Lane positioning matters here.
Elevation Profile
Mostly flat terrain
1,113 ft806 ft
Total Climb
660 ft
Total Descent
762 ft
Highest Point
1,113 ft
~203.3 mi in
Elevation Range
307 ft
Towns Mentioned on Route Signs
Based on OSRM destination-sign hints, not a full list of every settlement the road passes.
Between New Berlin, WI and Whitehall, WI, road signs point toward Eau Claire, Saint Paul and Pigeon Falls.
Whitehall Township is a suburban township near Allentown in the Lehigh Valley region of eastern Pennsylvania. The township is 64.1 miles (103.2 km) north of Philadelphia, the sixth-largest city in the United States, and 93.7 miles (150.8 km) west of New York City, the nation's largest city.
Doable as a same-day drive at 4h 5m. Total distance: 219 miles.
Family Friendly
Moderate complexity with 1 natural rest stops along the way.
Solo Traveler
4h 5m drive, comfortable solo distance.
First-Time Driver
Mostly highway driving (95%). Some complex stretches to watch for.
Frequently Asked Questions
The longest stretch is about 77.5 miles on I 94. The full list of main roads is in the Roads section above.
Yes — we found about 18 rest areas or service plazas within a short detour of the route (from OpenStreetMap). See the Rest Stops tab under Nearby Places for locations and mile markers. Plan to stretch, use the bathroom, and top off fluids every 2–3 hours on longer drives.
It helps. This route has a higher-than-average number of complex decision points, which get harder in the dark. If the last hour of the trip is on surface roads or mountain grades, aim to arrive at Whitehall, WI before sunset when you can. Check the Trip Plan for departure windows that land you in daylight.
Only with planning. This is a long drive for kids — consider splitting it into two days rather than pushing through. Plan at least 1 meaningful breaks. There are 18 rest areas along the route for bathroom stops.
The main spots that need attention: at 10.6 miles (I 94 / East-West Freeway): Highway fork - watch signs carefully. Lane positioning matters here; at 64.1 miles (I 94): Highway fork - watch signs carefully. Lane positioning matters here. Multiple destination signs - pick the right one; at 93.2 miles (I 90; I 94): Highway fork - watch signs carefully. Lane positioning matters here.
Yes — Ice Age National Scenic Trail. See the National Parks section for detour distances and tips on detours.
Possible but tiring. At 4.1 hours each way, an in-and-out day trip would put you behind the wheel for 8.2 hours — manageable with a long break at Whitehall, WI, but most travelers stay overnight.
