Elmhurst, IL to Frankfort, IL is 312.2 miles and takes about 5h 50m via I 57, with a fuel budget near $48 and enough daylight to finish in a day. This drive stays entirely within Illinois, connecting two points in the Midwest region. Expect a straightforward trip primarily on major highways, making it a good option if you're looking for efficiency. With just one recommended stop and a short estimated duration, this route is well-suited for a single-day excursion. It's a practical choice for getting from point A to point B without much fuss.
Trip Pace
Same-day drive is realistic
A same-day return is possible, but it will make for a full day on the road.
Break Rhythm
1 planned break
Plan on a short reset every 3 to 4 hours to stay fresh behind the wheel.
Midpoint
156.1 miles from Elmhurst, IL
A natural place for your longest stop of the day
, about 3h into the drive
.
Main Roads
Road
Distance
Duration
I 57
254.2 mi
4h 34m
Ken Gray Expressway
27.1 mi
29m
Tri-State Tollway
18.2 mi
23m
Cicero Avenue
4.9 mi
7m
West Main Street
2.5 mi
3m
Mile-Long Bridge
0.9 mi
1m
East Saint Charles Road
0.9 mi
1m
South York Street
0.6 mi
1m
Longest stretch:
I 57
— 254.2 mi, about 4h 34m
Traffic on I-57
Hour-of-day weekday pattern from 24 FHWA count stations on your route.
Peak
3 PM
~1,001 veh/hr typical
· worst 1,389
Quietest
2 AM
~168 veh/hr
Peak-to-quiet ratio
6×
busier at peak than in the quiet hours
12a6anoon6p11p
Averaged across 99 weeks of 2023 FHWA Travel Monitoring Analysis System data. Weekday hours only (Mon–Fri).
Turn-by-Turn Driving Directions
Step-by-step road directions between Elmhurst, IL and Frankfort, IL.
1
Start on this road
267 ft·25 sec·this road
2
Turn left
51 ft·9 sec
3
Turn left onto West Park Avenue
362 ft·13 sec·West Park Avenue
4
Turn right onto South York Street
0.6 mi·1 min·South York Street
5
Turn left onto East Saint Charles Road
0.9 mi·1 min·East Saint Charles Road
Use the left lane.
6
Take the ramp
0.3 mi·33 sec
Toward I 290 East
7
Merge onto I 290
0.3 mi·28 sec·I 290
8
Take the exit
0.3 mi·40 sec
Exit 15AToward I 88 West, I 294 South: Aurora, IndianaUse the straight / slight right lanes.
9
Continue on I 294
0.4 mi·47 sec·Tri-State Tollway
Exit 15AToward I 88 West, I 294 South: Aurora, Indiana
10
Keep slight left at fork onto I 294
1.0 mi·2 min·Tri-State Tollway
Toward I 88 West, I 294 South: Aurora, Indiana
11
Merge onto I 294
137 ft·1 sec·Tri-State Tollway
12
Keep slight left at fork onto I 294
4.8 mi·5 min·Tri-State Tollway
13
Keep slight right at fork onto I 294
3.5 mi·4 min·Tri-State Tollway
Use the straight / slight right lanes.
14
Continue on I 294
0.9 mi·1 min·Mile-Long Bridge
15
Continue on I 294
8.5 mi·10 min·Tri-State Tollway
Use the straight / slight right lanes.
16
Take the exit
0.2 mi·28 sec
Exit 12 B-AToward IL 50 South, IL 83: Cicero Avenue, 127th StreetUse the straight / slight right lanes.
17
Keep slight left at fork
0.5 mi·1 min
Exit 12AToward IL 50 South: Cicero AvenueUse the straight lane.
18
Turn straight onto IL 50; IL 83
4.9 mi·7 min·Cicero Avenue
Use the left lane.
19
Turn left onto 167th Street
0.2 mi·26 sec·167th Street
Use the left lane.
20
Take the ramp
0.6 mi·1 min
Toward I 57 South: Kankakee, I-80
21
Merge onto I 57
188 mi·3 hr 23 min·I 57
Use the straight / slight right lanes.
22
Keep slight left at fork onto I 57
66 mi·1 hr 10 min·I 57
Toward I 57 South: Memphis
23
Keep slight right at fork onto I 57
27 mi·29 min·Ken Gray Expressway
24
Take the exit
0.3 mi·34 sec
Toward IL 149: West Frankfort, Zeigler
25
Enter roundabout onto IL 149
0.2 mi·16 sec·West Main Street
26
Continue on IL 149
2.3 mi·3 min·West Main Street
27
Turn left onto North Benton Road
0.1 mi·36 sec·North Benton Road
28
Turn right onto East Saint Louis Street
98 ft·4 sec·East Saint Louis Street
29
Arrive at destination
East Saint Louis Street
Trip Plan
Since this drive is under 6 hours, you can comfortably complete it in one day. Leaving Elmhurst in the morning, perhaps around 9 AM, should allow you to arrive in Frankfort by mid-afternoon, giving you plenty of daylight. The longest stretch on I 57 is over 250 miles, so plan to take your one recommended stop sometime during that portion to stretch your legs. Keep an eye on your fuel gauge as you approach the final 50 miles, particularly if you're driving a less fuel-efficient vehicle, to ensure you have enough to reach your destination without needing an unscheduled stop. The estimated fuel cost is around $48.
Morning Departure
An early start around 7-8 AM gets you there with plenty of daylight left.
Evening Departure
A late afternoon start means arriving after dark. Morning is better.
You can normally do this drive in one day.
Plan roughly 1 meaningful break for fuel, food, and rest.
The halfway point lands around 156.1 miles from Elmhurst, IL, or about 3h into the drive.
The longest continuous stretch on this route runs about 254.2 miles.
This is a comfortable same-day trip.
Departure
Before you leave
Start with fuel, water, and navigation already sorted so the first hour feels easy.
First stop
Around 69 miles or 1h 25m in
Use this first pause for coffee, a restroom break, and a quick traffic check ahead.
Halfway reset
Around 156.1 miles or 3h in
This is the best place for your longest stop, a real meal, and a full fuel check.
Final approach
Final hour starts around 4h 47m
Traffic, exits, and arrival timing usually matter more near Frankfort, IL than in the middle of the route.
Before You Leave
+
Open the route before leaving Elmhurst, IL so your first major turns are already loaded.
+
Leave with enough water and a charging cable within reach, not packed away.
+
Check your fuel range against the first long segment, especially if you are starting outside city service areas.
Day 1
Settle into the route from Elmhurst, IL
This is one driving day of about 312.2 miles and 5h 50m.
Your first comfortable stop window is around 69 miles from Elmhurst, IL.
This route can stay practical as a one-day drive if traffic stays reasonable.
Plan about 1 real break rather than only quick fuel stops.
The longest stretch is on I 57 for about 254.2 miles.
Where to Stop
Rest stops, refuel points, and overnight suggestions along this route.
Place data sourced from public business listings. Hours and availability may vary.
Heads-up: tricky spots
5 of 24
5 decision points cluster between mile 2.2 and 21.9 — GPS handles the exact turns, but know they're coming. Your lane choice matters more than the turn itself.
8
2.2 mi into trip|~4m in
Take the exit toward I 88 West, I 294 South: Aurora, Indiana
Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one
Use the straight / slight right lanes.
Exit 15A
Toward I 88 West, I 294 South: Aurora, Indiana
6
2.9 mi into trip|~6m in|I 294 / Tri-State Tollway
Keep slight left at fork onto I 294 / Tri-State Tollway toward I 88 West, I 294 South: Aurora, Indiana
Highway fork - watch signs carefully. Multiple destination signs - pick the right one
Toward I 88 West, I 294 South: Aurora, Indiana
6
8.8 mi into trip|~14m in|I 294 / Tri-State Tollway
Keep slight right at fork onto I 294 / Tri-State Tollway
Highway fork - watch signs carefully. Lane positioning matters here
Use the straight / slight right lanes.
8
21.7 mi into trip|~30m in
Take the exit toward IL 50 South, IL 83: Cicero Avenue, 127th Street
Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one
Use the straight / slight right lanes.
Exit 12 B-A
Toward IL 50 South, IL 83: Cicero Avenue, 127th...
8
21.9 mi into trip|~30m in
Keep slight left at fork toward IL 50 South: Cicero Avenue
Highway fork - watch signs carefully. Lane positioning matters here
Use the straight lane.
Exit 12A
Toward IL 50 South: Cicero Avenue
Fuel & Cost
Regular Gas
$52.08 one way
$104.16 round trip
$4.24/gal25.4 MPG avg109 kg CO2
Fuel Type
$/gal
One Way
Round Trip
midgrade
$4.62
$56.82
$113.65
premium
$5.25
$64.57
$129.13
diesel
$6.28
$77.14
$154.28
Estimated Tolls: $1.09
Tri-state Tollway
(18.2 mi)$1.09
Toll estimates based on average 2024-2025 rates. EZ-Pass/SunPass discounts may lower the actual cost.
Estimated Trip Cost (one way, 1 person)
Fuel
$52
Tolls
$1
Meals
$25–$50
Total
$78–$103
Rough estimate based on US averages. Hotel $80–$140/night, meals $25–$50/day.
Estimated CO2 emission: 109.2 kg one way.
Prices: EIA weekly data, 2026-10-19.
Driving Electric?
About $33 in charging
· 1 stop
· 66% less CO2
Vehicle Type
kWh
Stops
DC Fast
Home Charge
Average EV
93.7
1
$32.78
$14.99
Efficient EV
78.1
0
$27.32
$12.49
EV Truck/SUV
124.9
1
$43.71
$19.98
Gas CO2
109 kg
EV CO2
37 kg (66% less)
Plan for 1 charging stop. A 30-minute DC fast charge mid-route should be enough to complete the trip comfortably.
DC fast charging avg $0.35/kWh. Home charging avg $0.16/kWh. US grid CO2: 0.39 kg/kWh.
Travel Intel
Current conditions at both ends of the drive.
Forecast as of Oct 22, 2026
Origin
Elmhurst, IL
Late night
in Elmhurst on Friday
Local time
5:07 AM
CDT
Current temp
49°F
Clear
0 mph0% chanceLive forecast
Destination
Frankfort, IL
Late night
in Frankfort on Friday
Local time
5:07 AM
CDT
Current temp
45°F
Clear
0 mph0% chanceLive forecast
Seasonal Notes
Summer travel usually means heavier construction, hotter rest stops, and busier weekend traffic around major cities.
Winter travel shortens daylight, so a route that looks manageable on paper can feel much longer after dark.
Holiday weekends tend to make both departure and arrival windows slower than the raw route time suggests.
Time zone
Same local time
Origin and destination are on the same clock, so arrival timing is easier to judge at a glance.
Temperature spread
4 degrees cooler at arrival
A meaningful temperature swing is a good cue to rethink layers, water, and how soon you want to arrive.
Road read
5h 50m on the road
An early start around 7-8 AM gets you there with plenty of daylight left.
Weather data from the National Weather Service. Conditions may change; check closer to your travel date.
National Parks Near This Route
Worth a detour if your schedule allows.
Pullman National Historical Park
National Historical Park
In a growing Chicago neighborhood, diverse people and stories intertwined. All were seeking opportunity. Some succeeded. Others were limited—by race, gender, or economic status. Their stories came tog...
8 mi from route
~19 min detour
Free
near mile 21.5
Park data from the National Park Service API. Alerts update every 2 hours.
More Details
What kind of drive is this?
This route is almost entirely highway driving, with 90% of the 312.2 miles on major roads like I 57. You'll experience a long stretch of 254.2 miles on I 57, which means extended periods of cruising. Expect a high volume of exits and interchanges as you navigate the expressways and tollways. The transition to surface roads will occur towards the end of your trip.
90% highway — fuel and pacing are the main things to plan.
29 navigation steps total — most of the decisions cluster near the start and finish.
Longest single stretch: 254.2 mi on I 57.
How Hard Is This Drive?
9/10
This is a straightforward highway drive that stays mostly on I 57 and Ken Gray Expressway. This route has several spots where lane changes, forks, or exits need your full attention. The trickiest moment comes around 2.2 miles in.
Driving Effort9/10
High effort - long or complex enough to need steady focus all day
Balances navigation complexity with total wheel time.
This is a demanding drive. With 24 significant decision points across 312.2 miles, you will need to stay alert - especially through interchange areas and urban stretches. Consider splitting it into segments if you are not comfortable with fast highway navigation.
Where does it get tricky?
The main spots that need attention: at 2.2 miles: Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one; at 2.9 miles (I 294 / Tri-State Tollway): Highway fork - watch signs carefully. Multiple destination signs - pick the right one; at 8.8 miles (I 294 / Tri-State Tollway): Highway fork - watch signs carefully. Lane positioning matters here.
Doable as a same-day drive at 5h 50m. Total distance: 312.2 miles.
Family Friendly
Moderate complexity with 1 natural rest stops along the way.
Solo Traveler
5h 50m drive, comfortable solo distance.
First-Time Driver
Mostly highway driving (90%). Some complex stretches to watch for.
Frequently Asked Questions
The longest stretch is about 254.2 miles on I 57. The full list of main roads is in the Roads section above.
Expect about $1.09 in tolls one way, starting with Tri-state Tollway. Most Northeast and Midwest toll agencies accept E-ZPass; in the West and Texas, transponders like TxTag or FasTrak apply. If you do not have a transponder, cashless tolling plates will mail a bill to the vehicle's registered address — usually with a surcharge, so a rental-car toll pass is often cheaper than paying by mail.
Yes — we found about 44 rest areas or service plazas within a short detour of the route (from OpenStreetMap). See the Rest Stops tab under Nearby Places for locations and mile markers. Plan to stretch, use the bathroom, and top off fluids every 2–3 hours on longer drives.
It helps. This route has a higher-than-average number of complex decision points, which get harder in the dark. If the last hour of the trip is on surface roads or mountain grades, aim to arrive at Frankfort, IL before sunset when you can. Check the Trip Plan for departure windows that land you in daylight.
Only with planning. This is a long drive for kids — consider splitting it into two days rather than pushing through. Plan at least 1 meaningful breaks. There are 44 rest areas along the route for bathroom stops.
The main spots that need attention: at 2.2 miles: Exit ramp - move to the correct lane early. Lane positioning matters here. Multiple destination signs - pick the right one; at 2.9 miles (I 294 / Tri-State Tollway): Highway fork - watch signs carefully. Multiple destination signs - pick the right one; at 8.8 miles (I 294 / Tri-State Tollway): Highway fork - watch signs carefully. Lane positioning matters here.
Yes — Pullman National Historical Park. See the National Parks section for detour distances and tips on detours.
Not recommended in a single day. At 5.8 hours each way, a round trip means 11.7 hours of driving — that is an unsafe level of fatigue for most drivers. Plan at least one night at Frankfort, IL before the return drive.
